With the development of the times, the electronic industry has developed on the basis of the development and application of Electronic Science and technology. Electronic industry is one of the pillar industries of the national economy, and it is also an emerging science and technology development industry. The protection of cables will be particularly important. The use of cable tray can play a role in cable dust prevention, corrosion prevention and other damage to the service life of cables.

下面为大家整理了如何修复和保护电缆桥架，使其延长使用寿命同时降低维修的费用。

The following is how to repair and protect the cable tray to prolong its service life and reduce the maintenance cost.

电缆桥架防腐

Corrosion prevention of cable tray

一、锈迹处理

1. Rust treatment

通常电缆桥架采用氯磺化底漆二道进行两部分除锈，表面除锈处理质量直接影响防腐工程的寿命，现场除锈通常是砂轮机或者人工除锈，在表面处理之后，在4小时内涂上底漆。如果处理不当发现有新锈进行重新处理。

Generally, the cable tray adopts two coats of chlorosulfonated primer for two-part derusting. The quality of surface derusting treatment directly affects the service life of the anti-corrosion project. The on-site derusting is usually done by grinder or manual derusting, and the primer is applied within 4 hours after the surface treatment. If new rust is found after improper treatment, it shall be treated again.

2.涂层处理

2. Coating treatment

涂层工艺分为刷涂、滚涂。刷涂或者滚涂时每层应纵横交错反复进行涂，直到均匀为止，不能出现漏涂。

The coating process is divided into brush coating and roller coating. When brushing or rolling, each layer shall be applied repeatedly in a crisscross manner until it is uniform, and there shall be no holiday.

3.施工环境要求

3. Construction environment requirements

环境需要通风良好，温度在13℃-30℃，不得低于5℃，相对湿度保持在80%以内。不宜在强烈日光下施工。遇到雨、雾、强风气候不得在室外进行施工。

The environment needs good ventilation, the temperature is 13 ℃ -30 ℃, not less than 5 ℃, and the relative humidity is kept within 80%. It is not suitable to construct under strong sunlight. In case of rain, fog and strong wind, construction shall not be carried out outdoors.

1.避免摆放在高温潮湿地方。

1. Avoid placing in hot and humid places.

2.避免与腐蚀性液体接触。

2. Avoid contact with corrosive liquids.

3.可用电缆桥架专用的保养蜡进行保养。

3. The special maintenance wax for cable tray can be used for maintenance.

4.定期清理电缆桥架表面的灰尘与锈迹。

4. Regularly clean the dust and rust on the surface of cable tray.

以上就是为大家介绍的有关山东电缆桥架的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.sdhangfeng.com

The above is a detailed introduction about Shandong cable tray, which I hope will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.sdhangfeng.com